Conservative treatment outcome for Achilles tendon re-rupture occurring in the subacute phase after primary repair.

Introduction: Until now, a treatment protocol for Achilles tendon re-rupture (ATRR) occurring in the postoperative period 5-12 weeks following primary Achilles tendon repair has not been established. We refer to this time frame as the subacute postoperative phase, and the objective of this study was to assess the efficacy of conservative treatment for subacute ATRR in this phase.

Materials And Methods: We conducted a retrospective review of 390 cases (385 patients) who had undergone primary Achilles tendon repair using the 4-strand Krachow method between January 2010 and August 2021. All patients were subjected to more than 12 months of follow-up and were categorized into two groups based on the presence of subacute ATRR: Group 1 comprised 370 cases without ATRR, while Group 2 comprised 20 cases with ATRR. Following confirmation of ATRR, we immediately applied a below-knee cast in an ankle plantar flexed position (25°-30°), followed by bracing according to the same rehabilitation plan used for the primary repair. After administering conservative treatment to the patients with ATRR, we compared several outcome parameters between the two groups, including isokinetic plantar flexion power measured using a dynamometer, time required for a single heel raise (t-SHR), time needed for ten repetitive SHRs (t-SHR10), Achilles Tendon Total Rupture Score (ATRS), and Foot and Ankle Ability Measure (FAAM) scores. The baseline timepoints for Groups 1 and 2 were the dates of the primary repair and the re-injury event.

Results: After primary Achilles tendon repair, subacute ATRR occurred in 5.1% of patients. There were no significant differences between the groups in terms of t-SHR and t-SHR10 (P = 0.281, 0.486). Similarly, the isokinetic dynamometer measurements revealed no significant differences in peak torque for plantar flexion at angular velocities of 30°/s and 120°/s, both in absolute values and as a percentage of the contralateral side, between the groups (P > 0.05 for each). However, ATRSs were significantly lower in Group 2 compared to Group 1 before 6 months (P < 0.05), as were FAAM-Activities of Daily Living scores at 6 months (P < 0.05). After 12 months, there were no significant differences in these scores between the two groups (both P > 0.05).

Conclusion: Conservative treatment for subacute ATRR following primary Achilles tendon repair yields clinical outcomes comparable to those without ATRR. Therefore, we recommend that surgeons consider relying on the patient's natural healing capabilities rather than opting for aggressive surgical interventions, as expediting such operations may be unnecessary for subacute injuries.