Biodistribution and respiratory toxicity of chloromethylisothiazolinone/methylisothiazolinone following intranasal and intratracheal administration.

A variety of isothiazolinone-containing small molecules have been registered and used as chemical additives in many household products. However, their biodistribution and potential harmful effects on human health, especially respiratory effects, were not yet identified in sufficient detail. The purpose of this study was to investigate whether a biocide comprising a mixture of chloromethylisothiazolinone (CMIT) and methylisothiazolinone (MIT) could reach the lungs and induce lung injury when exposure occurs by two administration routes involving the respiratory tract: intratracheal and intranasal instillation. To investigate the biodistribution of CMIT/MIT, we quantified the uptake of C-labeled CMIT/MIT in experimental animals for up to seven days after intratracheal and intranasal instillation. In the toxicity study, lung injury was assessed in mice using total inflammatory cell count in bronchoalveolar lavage fluid (BALF) and lung histopathology. The results of the biodistribution study indicated that CMIT/MIT were rapidly distributed throughout the respiratory tract. Using quantitative whole-body autoradiogram analysis, we confirmed that following intranasal exposure, CMIT/MIT reached the lungs via the respiratory tract (nose-trachea-lung). After 5 min post intratracheal and intranasal instillation, the amount of radiotracer ([C]CMIT/MIT) in the lungs was 2720 ng g and 752 ng g tissue, respectively, and lung damage was observed. A higher amount of the radiotracer resulted in higher toxicity. Both intratracheal and intranasal instillation of CMIT/MIT increased inflammatory cell counts in the BALF and induced injuries in the alveoli. The frequency and the severity scores of injuries caused by intratracheal instillation were approximately-four to five times higher than those induced by intranasal instillation. Therefore, we concluded that CMIT/MIT could reach the lungs following nasal and intratracheal exposure and cause lung injuries, and the extent of injury was dependent on the exposure dose.