Effect of algal contact time and horizontal water velocity on the performance of Filamentous Algal Nutrient Scrubbers (FANS).

We investigated the effect of algal contact time (ACT) and horizontal water velocity (HWV) on the performance of pilot-scale Filamentous Algae Nutrient Scrubbers (FANS) treating river water during the NZ summer. The FANS floways were seeded with a mixture of four New Zealand native filamentous algal species (Oedogonium sp., Cladophora sp., Rhizoclonium sp., and Spirogyra sp.) and allowed to establish over one month. River water was pumped onto the top of each FANS at different flow rates (2, 4 or 8 L min) to give ACTs from 0.6 to 10.1 min depending on FANS length (6-24 m) and HWV from 0.04 to 0.16 m s. FANS inflow and final outflows were monitored three times a week for nitrate and DRP concentrations and FANS algal biomass was harvested weekly. Average biomass productivity was significantly higher on the FANS with shorter ACT. For example, biomass productivity of the 24 m length FANS with 2.5 min ACT were 67% higher (11.2 g DW m d) than that with four times the ACT (10.1 min). Irrespective of the HWV the biomass productivity declined down the length of the floways (with longer ACT) and the decline was greater at lower HWV. The decreased biomass productivity at lower HWV (and/or higher ACT) was likely attributable to the daytime carbon limitation of photosynthesis (at pH > 9.5) and heat stress with elevated daytime water temperature (at >30 °C). Despite the short ACT (<10.1 min) the single pass pilot-scale FANS effectively removed both nitrate-N and DRP from the river water, with >35% removal of both NO-N (from 0.49 to <0.32 mg N L) and DRP (from 0.14 to <0.09 mg P L). Both the nitrogen and phosphorus content of the harvested algal biomass were unaffected by both HWV and ACT and typical (N: ∼2.0%; P: 0.2-0.3%) of the literature values (N: 1.5-3.0%; P: 0.15-0.32%). Compared with constructed wetland nutrient removal (0.1 g N m d; 0.08 g P m d), the FANS achieved up to 2.5-fold higher nitrogen removal (0.24 N m d) through algal nitrogen assimilation followed by subsequent algal harvest and up to 4-fold higher phosphorus removal (0.34 g P m d) through a combination of algal phosphorus assimilation and some P-precipitation under photosynthesis-mediated elevated daytime pH levels (pH > 9.0). This research indicates that FANS have the potential to require less than half the land area of constructed wetlands for the same level of nitrogen removal and that they require only a few weeks to establish to achieve full performance. Moreover, FANS have the further benefit of resource recovery for beneficial re-use of harvested algal biomass for animal feed, fertiliser, or biofuel.