Unlabelled: The objectives of this work were to determine the effect of 3 levels of residual air and 2 different retort motions on the value of the average heating slope of the rate of heat penetration of 3 different viscosities of a food simulant in flexible retort pouches. Pouches were thermally processed in a water spray automated batch retort system using 2 different methods of motion: static and oscillating continuously at a speed of 10.5 rotations per min (RPM) with an angle of 15°. Nine residual air and viscosity combinations were processed during each experimental run: low viscosity with no residual air (LV-NRA), medium viscosity with no residual air (MV-NRA), high viscosity with no residual air (HV-NRA), low viscosity with medium residual air (LV-MRA), medium viscosity with medium residual air (MV-MRA), high viscosity with medium residual air (HV-MRA), low viscosity with high residual air (LV-HRA), medium viscosity with high residual air (MV-HRA), and high viscosity with high residual air (HV-HRA). As the amount of residual air in the pouches increased, the average heating slope value decreased in both static and oscillating motions. As the viscosity of the product increased the amount of residual air affected the average heating slope less in static and oscillating motions. Overall, the oscillating motion resulted in faster rates of heat penetration in all viscosities compared to static mode. The oscillating motion reduced processing times up to 27% compared to static mode.
Practical Application: This research can be applied to food manufacturers that are retorting foods in pouches. Residual air in pouches has been studied previously; however, with the development of new retort motions, more research needs to be conducted about the effect of residual air in a pouch using the different motions. Food manufacturers can use this information to optimize their amount of residual air based on their product viscosity and retort motion. This could dramatically lower processing time which would save money and increase output as well as potentially increases product quality. This research is aimed at influencing food manufacturers, process authorities, and product developers.
Download full-text PDF |
Source |
|---|---|
| http://dx.doi.org/10.1111/1750-3841.13963 | DOI Listing |
Publication Analysis
Top Keywords
Similar Publications
Joint exposure to multiple air pollutants and residual cardiovascular risk in hypertension.
Ecotoxicol Environ Saf
January 2025
Health Management Center, The Third Xiangya Hospital, Central South University, Changsha 410013, China; Clinical Research Center, The Third Xiangya Hospital, Central South University, Changsha, Hunan 410013, China; Faculty of Life Sciences & Medicine, King's College London, 150 Stamford Street, London SE1 9NH, UK. Electronic address:
Background: Despite the widespread availability of antihypertensive medications, residual cardiovascular risk of hypertension remained high. Limited studies have investigated the link between air pollution, particularly joint exposure to multiple air pollutants, with residual cardiovascular risk of hypertension.
Methods: 1981 hypertensive patients (≥ 18 years) from an ongoing longitudinal cohort in China, were enrolled between 2013 and 2019.
External negative pressure improves lung aeration in near-term rabbit kittens at risk of developing respiratory distress.
Front Pediatr
January 2025
The Ritchie Centre, Hudson Institute of Medical Research, Clayton VIC, Australia.
Introduction: As airway liquid is cleared into lung interstitial tissue after birth, the chest wall must expand to accommodate this liquid and the incoming air. We examined the effect of applying external positive and negative pressures to the chest wall on lung aeration in near-term rabbit kittens at risk of developing respiratory distress.
Methods: Rabbit kittens (30 days; term ∼31 days) were randomised into and groups.
A hybrid deep learning air pollution prediction approach based on neighborhood selection and spatio-temporal attention.
Sci Rep
January 2025
School of Architecture and Urban Planning, Beijing University of Civil Engineering and Architecture, Beijing, 100055, China.
Air pollution is a critical global environmental issue, further exacerbated by rapid industrialization and urbanization. Accurate prediction of air pollutant concentrations is essential for effective pollution prevention and control measures. The complex nature of pollutant data is influenced by fluctuating meteorological conditions, diverse pollution sources, and propagation processes, underscores the crucial importance of the spatial and temporal feature extraction for accurately predicting air pollutant concentrations.
View Article and Find Full Text PDFStabilizing Layered Oxide Cathodes Based on Universal Surface Residual Alkali Conversion Chemistry for Rechargeable Secondary Batteries.
Adv Mater
January 2025
College of Chemistry and Materials Engineering, Wenzhou University, Wenzhou, 325035, P. R. China.
Layered transition metal oxides (LTMOs) are attractive cathode candidates for rechargeable secondary batteries because of their high theoretical capacity. Unfortunately, LTMOs suffer from severe capacity attenuation, voltage decay, and sluggish kinetics, resulting from irreversible lattice oxygen evolution and unstable cathode-electrolyte interface. Besides, LTMOs accumulate surface residual alkali species, like hydroxides and carbonates, during synthesis, limiting their practical application.
View Article and Find Full Text PDFInvestigating causal associations between pork intake and multiple sclerosis using Mendelian randomization: Insights from large-scale GWAS data in European populations.
Nutr Health
January 2025
Department of Neurology, Municipal Hospital Affiliated to Taizhou University, Taizhou, Zhejiang Province, China.
Background: Observational studies propose associations between dietary factors and multiple sclerosis (MS). However, the causal nature of these relationships remains unclear. This study aims to determine whether nutritional factors causally influence MS risk through Mendelian randomization (MR) analysis.
View Article and Find Full Text PDFWant AI Summaries of new PubMed Abstracts delivered to your In-box?
Enter search terms and have AI summaries delivered each week - change queries or unsubscribe any time!