Background: Organizations are stockpiling respirators to prepare for an influenza pandemic. To understand better the effects of prolonged storage, this investigation evaluated the filtration efficiency of 21 different models of National Institute for Occupational Safety and Health (NIOSH)-certified disposable N95 filtering face piece respirators. These respirators had been stored in their original packaging for a period of at least 6 years in research laboratories and dry warehouse facilities, ranging in temperature between 15 degrees C and 32 degrees C and relative humidity between 20% and 80%.
Methods: Filter penetration was measured using an abbreviated version of the NIOSH respirator certification test incorporating a polydisperse sodium chloride aerosol at 85 L/min.
Results: Of the 21 respirator models tested, 19 models had both average penetration results of less than 5%. Mean initial penetration values ranged from 0.39% to 5.83%, whereas mean maximum penetration values ranged from 0.95% to 5.83%. There did not appear to be any correlation between the length of storage and failure to pass the filtration test.
Conclusion: Results indicate that most N95 filtering face piece respirators stored for up to 10 years at warehouse conditions will likely have expected levels of filtration performance and that the degree of filtration efficiency degradation is likely model specific.
Download full-text PDF |
Source |
|---|---|
| http://www.ncbi.nlm.nih.gov/pmc/articles/PMC7132679 | PMC |
| http://dx.doi.org/10.1016/j.ajic.2008.09.021 | DOI Listing |
Publication Analysis
Top Keywords
Similar Publications
Lessons learned in establishing and sustaining elastomeric half mask respirator-based respiratory protection programs: An impact evaluation.
J Occup Environ Hyg
December 2024
National Personal Protective Technology Laboratory, National Institute for Occupational Safety and Health, Pittsburgh, Pennsylvania.
Developing and overseeing Respiratory Protection Programs (RPPs) is crucial for ensuring effective respirator use among employees. To date, a gap exists in research that focuses on elastomeric half mask respirators (EHMRs) as the primary respirator in health delivery settings which would necessitate additional considerations in RPPs beyond the more common N95 filtering facepiece respirators. This paper presents lessons learned during a one-year impact evaluation with healthcare and first responder settings that received EHMRs from the Strategic National Stockpile in 2021 and 2022.
View Article and Find Full Text PDFImplantation of web-like cellulose nanofibrils on electrospun fibrous membrane for boosting filtration performance.
Int J Biol Macromol
December 2024
Shanghai Advanced Research Institute, Chinese Academy of Sciences, Shanghai 201204, China. Electronic address:
Air pollution such as particulate matter is always a serious threat to public health, thus many disposable and degradable air filters were designed to deal with this severe challenge avoiding the secondary pollution after discarding. Herein, inspired by the natural spider web structure, a hierarchical porous composite fibrous membrane containing web-like cellulose nanofibrils (CNF) was developed. The implanted porous CNF membranes with web-like among the inter-fiber voids of electrospun poly(ethylene-co-viny alcohol) fibrous membrane were realized via a layer-by-layer (LBL) method followed by an elevated-temperature drying, which exhibit a smaller diameter with one or two orders of magnitude reduction comparing with the substrate fibers.
View Article and Find Full Text PDFN95 Filtering Facepiece Respirator Reuse, Extended Use, and Filtration Efficiency.
JAMA Netw Open
October 2024
Department of Emergency Medicine, University of California, San Francisco.
Effects of N95 Masks Versus Surgical/Loop Masks on Arterial Blood Gases and Adverse Symptoms in Operating Room Staff During Prolonged Usage: A Pilot Study.
Cureus
September 2024
Anesthesiology, State University of New York Upstate Medical University, Syracuse, USA.
Article Synopsis
- The study investigates the effects of wearing N95 masks compared to loop/surgical masks on healthcare workers during long shifts, focusing on symptoms like fatigue and blood gas levels.
- It involved a survey and measurements of carbon dioxide and oxygen levels before and after shifts, with 39 subjects participating.
- Results indicated that those wearing N95 masks reported significantly higher fatigue levels, but no meaningful differences were found in arterial blood gas parameters between the two mask types.
Synthesis of a Quaternary Ammonium-Halamine and Preparation on the Modified Nanofibrous Filter with Superior Sterilization, Air Filtration, and Biodegradability.
ACS Appl Mater Interfaces
October 2024
College of Sericulture, Textiles and Biomass Sciences, Chongqing Biomass Fiber Materials and Modern Textile Engineering Technology Research Center, State Key Laboratory of Silkworm Genome Biology, Southwest University, Chongqing 400715, China.
The outbreak of the 2019 coronavirus pandemic has raised worldwide attention about self-protection from airborne diseases. Air filtration and wearing mask have been proven to be effective measures in reducing the pathogenic aerosol's transmission. Those lead to an increasing demand of high-efficient filters.
View Article and Find Full Text PDFWant AI Summaries of new PubMed Abstracts delivered to your In-box?
Enter search terms and have AI summaries delivered each week - change queries or unsubscribe any time!