Dynamic changes in anaerobic digester metabolic pathways and microbial populations during acclimatisation to increasing ammonium concentrations.

Transitions in microbial community structure in response to increasing ammonia concentrations were determined by monitoring mesophilic anaerobic digesters seeded with a predominantly acetoclastic methanogenic community from a sewage sludge digester. Ammonia concentration was raised by switching the feed to source segregated domestic food waste and applying two organic loading rates (OLR) and hydraulic retention times (HRT) in paired digesters. One of each pair was dosed with trace elements (TE) known to be essential to the transition, with the other unsupplemented digester acting as a control.

A Rapid, Sensitive, Low-Cost Assay for Detecting Hydrogenotrophic Methanogens in Anaerobic Digesters Using Loop-Mediated Isothermal Amplification.

Understanding how the presence, absence, and abundance of different microbial genera supply specific metabolic functions for anaerobic digestion (AD) and how these impact on gas production is critical for a long-term understanding and optimization of the AD process. The strictly anaerobic methanogenic archaea are essential for methane production within AD microbial communities. Methanogens are a phylogenetically diverse group that can be classified into three metabolically distinct lineages based on the substrates they use to produce methane.

Impact of low loading on digestion of the mechanically-separated organic fraction of municipal solid waste.

Changing waste management practice, introduction of new technologies, and population demographics and behaviour will impact on both quantity and composition of future waste streams. Laboratory-scale anaerobic digestion of the mechanically-separated organic fraction of municipal solid waste (ms-OFMSW) was carried out at relatively low organic loading rates (OLR), and results analysed using an energy modelling tool. Thermophilic operation with water addition and liquor recycle was compared to co-digestion with dilution water replaced by sewage sludge digestate (SSD); thermophilic and mesophilic mono-digestion were also tested at low OLR.

Data related to anaerobic digestion of bioplastics: Images and properties of digested bioplastics and digestate, synthetic food waste recipe and packaging information.

The data presented in this article are related to the research article entitled 'Degradation of some EN13432 compliant plastics in simulated mesophilic anaerobic digestion of food waste' (W. Zhang, S. Heaven, C.

Evaluation of pressurised carbon dioxide pre-treatment aimed at improving the sanitisation and anaerobic digestibility of co-settled sewage sludge.

This work reports on the use of pressurized CO pretreatment to improve methane yield and pathogen indicator organism die-off in co-settled sewage sludge (SS). Four semi-continuous mesophilic anaerobic digesters were fed on co-settled SS to establish a baseline for performance and stability. One pair of digesters was then fed with co-settled SS pretreated by P CO at 2800 kPa for 23 h.

Investigation of the impact of trace elements on anaerobic volatile fatty acid degradation using a fractional factorial experimental design.

The requirement of trace elements (TE) in anaerobic digestion process is widely documented. However, little is understood regarding the specific requirement of elements and their critical concentrations under different operating conditions such as substrate characterisation and temperature. In this study, a flask batch trial using fractional factorial design is conducted to investigate volatile fatty acids (VFA) anaerobic degradation rate under the influence of the individual and combined effect of six TEs (Co, Ni, Mo, Se, Fe and W).

Continuous operation of thermophilic food waste digestion with side-stream ammonia stripping.

Digesters fed on food waste (high nitrogen content) were operated successfully over an extended period using sidestream biogas stripping to control total ammonia nitrogen (TAN) below inhibitory concentrations. This is the first time biogas stripping has been used to achieve stable thermophilic operation with undiluted substrate of this type. Stripping columns operated batch-wise treated the equivalent of 1.

Quantifying the percentage of methane formation via acetoclastic and syntrophic acetate oxidation pathways in anaerobic digesters.

Ammonia concentration is one of the key factors influencing the methanogenic community composition and dominant methanogenic pathway in anaerobic digesters. This study adopted a radiolabelling technique using [2-C] acetate to investigate the relationship between total ammonia nitrogen (TAN) and the methanogenic pathway. The radiolabelling experiments determined the ratio of CO and CH in the biogas which was used to quantitatively determine the percentage of CH derived from acetoclastic and syntrophic acetate oxidation routes, respectively.

In situ biogas stripping of ammonia from a digester using a gas mixing system.

Previous studies have suggested the use of digester biogas mixing systems for in situ ammonia removal from anaerobic digestates. The feasibility of this was tested at moderate and complete gas mixing rates at mesophilic and thermophilic temperatures in a 75-L digester. Experimental results showed that at gas mixing rates typical of full-scale commercial digesters the reduction in total ammonia nitrogen concentrations would be insufficient to allow stable acetoclastic methanogenesis in mesophilic conditions, or to prevent total inhibition of methanogenic activity in thermophilic food waste digestion.

Effect of mean cell residence time on transmembrane flux, mixed-liquor characteristics and overall performance of a submerged anaerobic membrane bioreactor.

Kinetic control of Mean Cell Residence Time (MCRT) was shown to have a significant impact on membrane flux under steady-state conditions. Two laboratory-scale flat-plate submerged anaerobic membrane bioreactors were operated for 245 days on a low-to-intermediate strength substrate with high suspended solids. Transmembrane pressure was maintained at 2.

Biogas production from undiluted chicken manure and maize silage: A study of ammonia inhibition in high solids anaerobic digestion.

The feasibility of co-digestion of chicken manure (CM) and maize silage (MS) without water dilution was investigated in 5-L digesters. Specific methane production (SMP) of 0.309LCH4g(-1) volatile solids (VS) was achieved but only at lower %CM.

Anaerobic digestion of spring and winter wheat: Comparison of net energy yields.

Anaerobic digestion of wheat was investigated under batch conditions. The article compares the potential net energy yield between a winter wheat (sown in the autumn) and a spring wheat (sown in the spring) grown in the same year and harvested at the same growth stage in the same farm. The spring wheat had a slightly higher biochemical methane potential and required lower energy inputs in cultivation, but produced a lower dry biomass yield per hectare, which resulted in winter wheat providing the best overall net energy yield.

Development and testing of a fully gravitational submerged anaerobic membrane bioreactor for wastewater treatment.

A gravity-operated submerged anaerobic membrane bioreactor (SAnMBR) was set up in order to test its principle of operation as an alternative to conventional pumped permeation of the membrane. This operating mode allowed the membrane flux rate to be measured accurately whilst maintaining a constant transmembrane pressure (TMP), and allowed small transient variations in the flux rate to be observed. The reactor was operated at 36°C for a period of 115 days using a nutrient-balanced synthetic substrate with a high suspended solids concentration.

Comparison of mesophilic and thermophilic anaerobic digestion of sugar beet pulp: performance, dewaterability and foam control.

Digestion of sugar beet pulp was assessed in relation to biogas and methane production, foaming potential, and digestate dewaterability. Four 4-litre working volume digesters were operated mesophilically (37±0.5 °C) and four thermophilically (55±0.

Anaerobic digestion of autoclaved and untreated food waste.

Anaerobic digestion of autoclaved (160°C, 6.2 bar) and untreated source segregated food waste (FW) was compared over 473 days in semi-continuously fed mesophilic reactors with trace elements supplementation, at organic loading rates (OLRs) of 2, 3, 4 and 6 kg volatile solids(VS)/m(3)d. Methane yields at all OLR were 5-10% higher for untreated FW (maximum 0.

Improving the performance of enzymes in hydrolysis of high solids paper pulp derived from MSW.

Background: The research aimed to improve the overall conversion efficiency of the CTec® family of enzymes by identifying factors that lead to inhibition and seeking methods to overcome these through process modification and manipulation. The starting material was pulp derived from municipal solid waste and processed in an industrial-scale washing plant.

Results: Analysis of the pulp by acid hydrolysis showed a ratio of 55 : 12 : 6 : 24 : 3 of glucan : xylan : araban/galactan/mannan : lignin : ash.

The effect of pH control and 'hydraulic flush' on hydrolysis and Volatile Fatty Acids (VFA) production and profile in anaerobic leach bed reactors digesting a high solids content substrate.

The effect of hydraulic flush and pH control on hydrolysis, Volatile Fatty Acids (VFA) production and profile in anaerobic leach bed reactors was investigated for the first time. Six reactors were operated under different regimes for two consecutive batches of 28days each. Buffering at pH ∼6.

Effectiveness of pressurised carbon dioxide for inactivation of Escherichia coli isolated from sewage sludge.

This research explored the possible application of pressurised carbon dioxide (P CO(2)), a promising non-thermal sterilisation technique, for the treatment of sewage sludge (SS) before anaerobic digestion to inactivate pathogenic microorganisms. Escherichia coli was selected as the test organism and was isolated from SS and maintained in pure culture. The growth curve of the isolated strain was determined by measuring the optical density (OD) in liquid culture medium and relating this information to the spread plate count so that a culture of known cell density could be grown for optimisation experiments.

Anaerobic digestion of two biodegradable municipal waste streams.

Landfill avoidance for organic wastes is now a high priority worldwide. Two fractions of the municipal waste stream were considered with respect to their potential for diversion through controlled anaerobic digestion. The physical and chemical properties of source segregated domestic food waste (ss-FW) and of the mechanically-recovered organic fraction of municipal solid waste (mr-OFMSW) were analysed, and their methane yields determined in both batch and semi-continuous digestion.

Co-digestion of source segregated domestic food waste to improve process stability.

Cattle slurry and card packaging were used to improve the operational stability of food waste digestion, with the aim of reducing digestate total ammoniacal nitrogen concentrations compared to food waste only. Use of cattle slurry could have major environmental benefits through reducing greenhouse gas emissions associated with current management practices; whilst card packaging is closely linked to food waste and could be co-collected as a source segregated material. Both options increase the renewable energy potential whilst retaining organic matter and nutrients for soil replenishment.

Algal wastewater treatment systems for seasonal climates: application of a simple modelling approach to generate local and regional design guidelines.

Algal waste stabilisation ponds (WSP) provide a means of treating wastewater, and also a potential source of water for re-use in irrigation, aquaculture or algal biomass cultivation. The quantities of treated water available and the periods in which it is suitable for use or discharge are closely linked to climatic factors. This paper describes the application, at a continent-wide scale, of a modelling approach based on the use of readily available climate datasets to provide WSP design and performance guidelines linked to geographical location.

Trace element requirements for stable food waste digestion at elevated ammonia concentrations.

The work investigated why anaerobic digesters treating food waste and operating at high ammonia concentrations suffer from propionic acid accumulation which may result in process failure. The results showed deficiency of selenium, essential for both propionate oxidation and syntrophic hydrogenotrophic methanogenesis, leads to this while supplementation allows operation at substantially higher organic loading rates (OLR). At high loadings cobalt also becomes limiting, due to its role either in acetate oxidation in a reverse Wood-Ljungdahl or in hydrogenotrophic methanogenesis.

The role of phase separation and feed cycle length in leach beds coupled to methanogenic reactors for digestion of a solid substrate (Part 1): Optimisation of reactors' performance.

A two-phase system composed by a leach bed and a methanogenic reactor was modified for the first time to improve volumetric substrate degradation and methane yields from a complex substrate (maize; Zeamays). The system, which was operated for consecutive feed cycles of different durations for 120 days, was highly flexible and its performance improved by altering operational conditions. Daily substrate degradation was higher the shorter the feed cycle, reaching 8.

Integration of on-farm biodiesel production with anaerobic digestion to maximise energy yield and greenhouse gas savings from process and farm residues.

Anaerobic co-digestion of residues from the cold pressing and trans-esterification of oilseed rape (OSR) with other farm wastes was considered as a means of enhancing the sustainability of on-farm biodiesel production. The study verified the process energy yields using biochemical methane potential (BMP) tests and semi-continuous digestion trials. The results indicated that high proportions of OSR cake in the feedstock led to a decrease in volatile solids destruction and instability of the digestion process.