Fly Ash-Based Geopolymer Building Materials for Green and Sustainable Development.

This study reports on formulations and conditions for producing fly ash-based geopolymers with a view to showing that the compressive strength required for construction applications can be obtained without the addition of aggregates, sand, and/or cement. It was shown in a series of experiments constituting at least 73% fly ash that a compressive strength of up to 90 MPa can be obtained depending on the curing conditions. While high alkalinity resulted in stronger materials, the results showed about 40% savings in CO emissions without using sand and cement.

The leaching behaviour and geochemical fractionation of trace elements in hydraulically disposed weathered coal fly ash.

A five-step sequential extraction (SE) procedure was used to investigate the leaching behaviour and geochemical partitioning of the trace elements As, Zn, Pb, Ni, Mo, Cr and Cu in a 20-year-old fly ash (FA) dump. The weathered FA, which was hydraulically co-disposed with salt laden brine in slurry form (FA: brine ratio of 1:5), was analyzed and compared with fresh FA. The weathered FA samples were collected from three cores, drilled at a coal-fired power station in the Republic of South Africa while the fresh FA sample was collected from the hoppers in the ash collection system at the power station.

Chemical, mineralogical and morphological changes in weathered coal fly ash: a case study of a brine impacted wet ash dump.

The mobility of species in coal fly ash (FA), co-disposed with brine using a wet ash handling system, from a coal fired power generating utility has been investigated. The study was conducted in order to establish if the wet ash dump could act as a salt sink. The ash was dumped as a slurry with 5:1 brine/ash ratio and the dam was in operation for 20 years.

Comparison of CO2 capture by ex-situ accelerated carbonation and in in-situ naturally weathered coal fly ash.

Natural weathering at coal power plants ash dams occurs via processes such as carbonation, dissolution, co-precipitation and fluid transport mechanisms which are responsible for the long-term chemical, physical and geochemical changes in the ash. Very little information is available on the natural carbon capture potential of wet or dry ash dams. This study investigated the extent of carbon capture in a wet-dumped ash dam and the mineralogical changes promoting CO2 capture, comparing this natural phenomenon with accelerated ex-situ mineral carbonation of fresh fly ash (FA).