Upcycling Romaine lettuce outer leaves by infrared blanching and hot air drying.

Romaine lettuce outer leaves, as opposed to the more commonly marketed heart, are typically discarded and present an opportunity for upcycling as dried powders. Duquesne Romaine lettuce was evaluated to quantify and compare quality attributes of fresh outer and heart leaves, dried powders following hot air drying, and dried powders following an infrared (IR) blanching pretreatment before drying. Attributes measured for fresh leaves included moisture, water activity (A), color, total soluble phenolics (TSP), and antioxidant capacity (AC).

Extraction, Purification and In Vitro Antioxidant Activity Evaluation of Phenolic Compounds in California Olive Pomace.

Olive pomace (OP) is a valuable food byproduct that contains natural phenolic compounds with health benefits related to their antioxidant activities. Few investigations have been conducted on OP from the United States while many studies on European OP have been reported. OP of Arbequina, the most common cultivar from California, was collected and extracted by water, 70% methanol and 70% ethanol, followed by purification using macroporous absorbing resin.

Health benefits of first and second extraction drum-dried pitted olive pomace.

Olive pomace (OP) is the main by-product of olive oil extraction. After pit and skin removal, OP pulp has high concentrations of dietary fiber and phenolics with high antioxidant capacity. This study evaluated mice health benefits of drum-dried pitted OP pulp obtained after first and second oil extraction.

Consumer sensory evaluation and quality of Sorghum-Peanut Meal-Okra snacks.

Healthful tasty high protein, vegetable, gluten-free snacks are needed for all as well as those sensitive to gluten for in between meals and for after school events. Peanut meal a low value farm by-product was used to increase protein content and to add value for growers. Bile acid binding okra with cholesterol lowering potential and jalapeno, turmeric and ginger with healthy phytonutrients were included to increase vegetable consumption.

Mechanical and Thermal Behavior of Canola Protein Isolate Films As Improved by Cellulose Nanocrystals.

The effects of cellulose nanocrystals (CNCs) (12, 24, and 36% w/w) on the microstructure and mechanical and thermal properties of canola protein isolate films were evaluated. The incorporation of cellulose nanocrystals led to homogeneous films, and new Fourier transform infrared peaks appeared at 1055 cm, indicating the presence and the interaction of CNCs with proteins and glycerol. The addition of CNCs also improved the thermal stability of the films, since higher temperatures were required for their thermal decomposition.

High-Protein Nutritious Flatbreads and an Option for Gluten-Sensitive Individuals.

Whole grain quinoa and wheat, high-protein vegetable flatbreads were evaluated by tasters and a physical analysis was conducted. The objective was to produce nutritious, tasty gluten-free (quinoa) as well as gluten-containing (wheat) flatbreads. Flatbreads were Quinoa Peanut Oilcake Broccoli (QPCBROC), Wheat Peanut Oilcake Broccoli (WPCBROC), Quinoa Peanut Oilcake Beets (QPCBEET) and Wheat Peanut Oilcake Beets (WPCBEET).

Massaranduba Sawdust: A Potential Source of Charcoal and Activated Carbon.

This paper provides proof of concept that activated carbon (AC) may be readily produced using limited conversion methods and resources from sawdust of massaranduba () wood, thereby obtaining value-added products. Sawdust was sieved and heat-treated in an oxygen-free muffle furnace at 500 °C to produce charcoal. The charcoal was activated in a tubular electric furnace at 850 °C while being purged with CO gas.

Phenolics and Antioxidant Capacity of Pitted Olive Pomace Affected by Three Drying Technologies.

This study investigated drum-drying's ability to produce dried food-grade olive pomace as a potential food ingredient that is more nutritionally dense than its freeze-dried and hot-air dried counterparts. The pits and skin were removed from fresh olive pomace, and the remaining pulp was dried to <5% moisture through freeze-drying, hot-air drying, and drum-drying at two rotational speeds. The drying treatments had no significant (P ≤ 0.

Antimicrobial Carvacrol in Solution Blow-Spun Fish-Skin Gelatin Nanofibers.

Unlabelled: Carvacrol is a volatile monoterpenic phenol and main component of oregano essential oil that shows nonspecific antimicrobial activity against foodborne pathogenic bacteria. Fish-skin gelatin (FSG) nanofibers encapsulating carvacrol (15%, 20%, 25%, and 30%, w/w FSG) were successfully prepared via solution blow-spinning (SBS) technique using lecithin (2.475% wb) as the surfactant.

Preparation of Fish Skin Gelatin-Based Nanofibers Incorporating Cinnamaldehyde by Solution Blow Spinning.

Cinnamaldehyde, a natural preservative that can non-specifically deactivate foodborne pathogens, was successfully incorporated into fish skin gelatin (FSG) solutions and blow spun into uniform nanofibers. The effects of cinnamaldehyde ratios (5-30%, / FSG) on physicochemical properties of fiber-forming emulsions (FFEs) and their nanofibers were investigated. Higher ratios resulted in higher values in particle size and viscosity of FFEs, as well as higher values in diameter of nanofibers.

Recent Advances on Edible Films Based on Fruits and Vegetables-A Review.

Food packaging materials are traditionally expected to contain foodstuffs and protect them from deteriorating agents. Although petroleum-derived polymers have been widely used for this purpose, the rising concern with their nonrenewable and/or nonbiodegradable nature paves the route for the development of greener alternatives, including polysaccharides and polypeptides. The use of these food-grade biomacromolecules, in addition to fruits and vegetables, provides edible packaging with suitable physical-mechanical properties as well as unique sensory and nutritional characteristics.

Solution blow spun nanocomposites of poly(lactic acid)/cellulose nanocrystals from Eucalyptus kraft pulp.

Cellulose nanocrystals (CNCs) were extracted from Eucalyptus kraft pulp by sulfuric acid hydrolysis, and esterified with maleic anhydride (CNC). The incorporation of sulfate ester groups on the cellulose surface resulted in higher stability of the nanoparticles in aqueous suspensions and lower thermal stability. Then, PLA/CNC and PLA/CNC nanocomposites were successfully obtained by solution blow spinning (SBS) using dimethyl carbonate (DMC) as solvent.

Solution Blow Spinning of Food-Grade Gelatin Nanofibers.

The primary advantage of nanofibers over larger diameter fibers is the larger surface area to volume ratio. This study evaluated solution blow spinning (SBS) processing conditions for obtaining food-grade gelatin nanofibers from mammalian and fishery byproducts, such as pork skin gelatins (PGs) and high molecular weight fish skin gelatin (HMWFG). HMWFG had a highest intact collagen structure compared to PGs.

Sensory evaluation of gluten-free quinoa whole grain snacks.

Sensory evaluation of quinoa gluten-free whole grain low fat and salt snacks was conducted. The snacks were Quinoa, Quinoa-Cayenne Pepper, Quinoa-Ginger and Quinoa-Turmeric. Cayenne pepper, ginger and turmeric are common spices that contain health promoting nutrients.

Preparation of Zein Fibers Using Solution Blow Spinning Method.

Zein fibers were successfully fabricated via solution blow spinning (SBS) using acetic acid as solvent. Surface tension, viscosity and modulus of zein solutions were respectively determined by force tensiometer and rheometer. Increases of these properties were observed with an increase of concentration from 20% to 35% (w/w).

Torrefaction of pomaces and nut shells.

Apple, grape, olive, and tomato pomaces as well as almond and walnut shells were torrefied at different temperatures and times in a muffle furnace. The fiber content and thermal stability of the raw byproducts were examined and the moisture and ash contents, elemental composition, and gross calorific values of the raw and torrefied samples were characterized. Response surface methodology and a central composite design were used to examine the effects of temperature and time on mass and energy yields of the torrefied byproducts.

Physical and antibacterial properties of açaí edible films formulated with thyme essential oil and apple skin polyphenols.

Unlabelled: Thyme essential oil (TEO) and apple skin polyphenols (ASP) are natural compounds considered as generally recognized as safe by FDA, with biological effects against bacteria and fungi. This work aimed to evaluate physical and antimicrobial properties of açaí edible films formulated with TEO and ASP at 3% and 6% (w/w) individually or combined at 3% (w/w) each. Physical properties studied include mechanical resistance, water vapor permeability (WVP), color, and thermal resistance.

Optimization of antimicrobial and physical properties of alginate coatings containing carvacrol and methyl cinnamate for strawberry application.

Increasing strawberry consumption has led to a growing safety concern because they are not washed after harvest. An antimicrobial edible coating could be an effective postharvest technique to ensure microbial safety and, at the same time, retain overall quality of the fruits. Response surface methodology was used to optimize the antimicrobial activity against Escherichia coli O157:H7 and Botrytis cinerea and several physical properties (turbidity, viscosity, and whitish index) of an alginate coating.

Effect of UV-B light and different cutting styles on antioxidant enhancement of commercial fresh-cut carrot products.

Wounding stresses resulting from fresh-cut processing are known to enhance the antioxidant capacity (AC) of carrots by increasing the synthesis of phenolic compounds. Ultraviolet-B (UV-B) light exposure further promotes the formation of phenolic compounds. Changes in total soluble phenolics (TSP), 5-O-caffeoylquinic acid (5-CQA), total carotenoids, AC, and phenylalanine ammonia-lyase (PAL) activity of five commercial fresh-cut carrot products (baby carrots, carrot stixx, shredded carrots, crinkle cut coins, and oblong chips) were evaluated after exposure to UV-B dosage at 141.

Properties of electrospun pollock gelatin/poly(vinyl alcohol) and pollock gelatin/poly(lactic acid) fibers.

Pollock gelatin/poly(vinyl alcohol) (PVA) fibers were electrospun using deionized water as the solvent and pollock gelatin/poly(lactic acid) (PLA) fibers were electrospun using 1,1,1,3,3,3-hexafluoro-2-propanol (HFIP) as the solvent. The chemical, thermal, and thermal stability properties were examined for the electrospun samples. The electrospun PVA samples generally had thinner and more uniform fibers than the electrospun PLA samples.

Ultraviolet-B radiation induced cross-linking improves physical properties of cold- and warm-water fish gelatin gels and films.

Cold- and warm-water fish gelatin granules were exposed to ultraviolet-B radiation for doses up to 29.7 J/cm(2). Solutions and films were prepared from the granules.

Sensory evaluation of baked chicken wrapped with antimicrobial apple and tomato edible films formulated with cinnamaldehyde and carvacrol.

The addition of plant essential oils to edible films and coatings has been shown to protect against bacterial pathogens and spoilage while also enhancing sensory properties of foods. This study evaluated the effect of adding 0.5 and 0.

Ultraviolet-B light treatment increases antioxidant capacity of carrot products.

Background: The effect of ultraviolet-B (UV-B) light as a postharvest treatment to enhance the antioxidant content of carrots and fresh-cut carrot products was evaluated. Four levels of UV-B dose ranging from 1.3 to 12 kJ m⁻² were applied to whole, baby and various styles of cut carrots, and the changes in antioxidant capacity, total soluble phenolics and phenylalanine ammonia-lyase (PAL, EC 4.

Nanoemulsions prepared by a low-energy emulsification method applied to edible films.

Catastrophic phase inversion (CPI) was used as a low-energy emulsification method to prepare oil-in-water (O/W) nanoemulsions in a lipid (Acetem)/water/nonionic surfactant (Tween 60) system. CPIs in which water-in-oil emulsions (W/O) are transformed into oil-in-water emulsions (O/W) were induced by changes in the phase ratio. Dynamic phase inversion emulsification was achieved by slowly increasing the water volume fraction (fw) to obtain O/W emulsions from water in oil emulsions.

Dehydration of pollock skin prior to gelatin production.

Unlabelled: Alaska pollock (Theragra chalcogramma) is the U.S.A.