A pilot study of workplace dermal exposures to cypermethrin at a chemical manufacturing plant.

Exposure during the manufacture of pesticides is of particular concern due to their toxicity and because little is known about worker exposure, since most studies have focused on end-use application within agriculture or buildings. Even though dermal exposure can be expected to dominate for pesticides, little is known about workplace dermal exposures or even appropriate methods for their assessment. The current study begins to address this gap by evaluating alternative methods for assessing dermal exposure at a chemical manufacturing plant.

Sampling and analytical method development and hand wipe measurements of dermal exposures to polycyclic aromatic hydrocarbons.

This article describes the laboratory assessment of a hand and surface wipe sampling method for polycyclic aromatic hydrocarbons (PAHs). The analytical method employed extraction of the wipe samples into dimethyl sulfoxide (DMSO) and high-performance liquid chromatography (HPLC) flourometric detection of pyrene, a predominant PAH in used gasoline engine oils (UGEO). Recovery of pyrene was evaluated for two different sampling media by first contaminating the hands of a small number of volunteers with UGEO, followed by applying a small amount of corn oil to the palms, and by wiping the skin with a Whatman cellulostic filter paper or a polyester fabric wipe (i.

Community-based intervention to reduce pesticide exposure to farmworkers and potential take-home exposure to their families.

The US EPA Worker Protection Standard requires pesticide safety training for farmworkers. Combined with re-entry intervals, these regulations are designed to reduce pesticide exposure. Little research has been conducted on whether additional steps may reduce farmworker exposure and the potential for take-home exposure to their families.

DNA adducts in granulocytes of hospital workers exposed to ethylene oxide.

Background: Ethylene oxide (EtO), an important industrial chemical intermediate and sterilant, is classified as a human carcinogen. Occupational EtO exposure in many countries is regulated at 1 ppm (8-hr TWA), but levels of EtO-DNA adducts in humans with low occupational EtO exposures have not been reported.

Methods: We examined the formation of N7-(2'-hydroxyethyl)guanine (N7-HEG), a major DNA adduct of EtO, in 58 EtO-exposed sterilizer operators and six nonexposed workers from ten hospitals.

A comparison of surface wipe media for sampling lead on hands.

Hand contamination by toxic agents such as lead presents a potentially significant health hazard to workers if the contamination is transferred to the mouth by food, smoking, or touching the mouth. One method to sample the mass of contamination on hands is to wipe the skin and analyze the wipe media for the analyte. Several commercially available, prewetted wipe media were evaluated and compared.

Skin absorption of inorganic lead (PbO) and the effect of skin cleansers.

Objective: The aim of this study was to investigate the percutaneous penetration of lead oxide (PbO) powder and the effect of rapid skin decontamination with two different detergents.

Methods: Franz cells were used to study in vitro PbO skin penetration through human skin during a 24-hour period. The tests were performed without or with decontamination using either Ivory Liquid soap or a new experimental cleanser 30 minutes after the start of exposure.

An FTIR investigation of isocyanate skin absorption using in vitro guinea pig skin.

Isocyanates may cause contact dermatitis, sensitization and asthma. Dermal exposure to aliphatic and aromatic isocyanates can occur in various exposure settings. The fate of isocyanates on skin is an important unanswered question.

Urinary hexane diamine to assess respiratory exposure to hexamethylene diisocyanate aerosol: a human inhalation study.

The use of urinary hexane diamine (HDA) as a biomarker to assess human respiratory exposure to hexamethylene diisocyanate (HDI) aerosol was evaluated. Twenty-three auto body shop workers were exposed to HDI biuret aerosol for two hours using a closed exposure apparatus. HDI exposures were quantified using both a direct-reading instrument and a treated-filter method.

Federal government regulation of occupational skin exposure in the USA.

There are at least 14 federal regulations and three agencies that are involved in the regulation of occupational skin exposures in the USA. The Environmental Protection Agency (EPA) requires the reporting of health effects information on chemicals, and such information is used to assess the risks of human and environmental exposure. The health effects information and any resulting risk assessments are generally available to the public.

Methods for assessing risks of dermal exposures in the workplace.

The skin as a route of entry for toxic chemicals has caused increasing concern over the last decade. The assessment of systemic hazards from dermal exposures has evolved over time, often limited by the amount of experimental data available. The result is that there are many methods being used to assess safety of chemicals in the workplace.

In-use testing and interpretation of chemical-resistant glove performance.

Issuing gloves to workers is the most common approach to protecting against skin contact with hazardous chemicals. Typically, glove materials are selected and duration of wear is estimated based on comparisons of laboratory test data. Those who select the glove materials often fail to verify their selections by testing the glove during actual use.

A critique of assumptions about selecting chemical-resistant gloves: a case for workplace evaluation of glove efficacy.

Wearing chemical-resistant gloves and clothing is the primary method used to prevent skin exposure to toxic chemicals in the workplace. The process for selecting gloves is usually based on manufacturers' laboratory-generated chemical permeation data. However, such data may not reflect conditions in the workplace where many variables are encountered (e.

Indoor particles and symptoms among office workers: results from a double-blind cross-over study.

Background: We studied the effects of removing small airborne particles in an office building without unusual contaminant sources or occupant complaints.

Methods: We conducted a double-blind crossover study of enhanced particle filtration in an office building in the Midwest United States in 1993. We replaced standard particle filters, in separate ventilation systems on two floors, with highly efficient filters on alternate floors weekly over 4 weeks.