Presence, Co-Occurrence, and Daily Intake Estimates of Aflatoxins and Fumonisins in Maize Consumed in Food-Insecure Regions of Western Honduras.

Foodborne mycotoxins are a significant food safety risk in developing countries. Our objective was to determine the occurrence of and exposure levels to aflatoxins (AFs) and fumonisins (FBs) in maize intended for human and animal consumption in food-insecure regions of western Honduras. Total AFs and FBs were quantified with a monoclonal antibody-based affinity spectrofluorimetric method.

Quantitative modeling of the survival of Listeria monocytogenes in soy sauce-based acidified food products.

Primary and secondary models were developed for quantitatively characterizing the survival of Listeria monocytogenes in soy-sauce based acidified Asian style products that do not undergo a thermal treatment. The objective of this study was to quantify the effect of food matrix properties on L. monocytogenes' survival in soy sauce-based products.

Incidence of aflatoxins and fumonisins in grain, masa and corn tortillas in four municipalities in the department of Lempira, Honduras.

In Honduras, corn is the most important staple food for the majority of the population. This high-demand crop is susceptible to biological contamination with mycotoxins, which could represent a latent hazard for consumers. To assess the incidence of aflatoxins and fumonisins in grain, masa and tortilla, and the dietary exposure to these substances among consumers, a study was conducted in four municipalities in the department of Lempira.

Stability of fumonisin B1 and its bioaccessibility in extruded corn-based products.

Fumonisins are a group of mycotoxins commonly associated with corn-based products and require innovative alternatives to control exposure to its toxicity. The objective of this research was to determine the effect of amylose and resistant starch on fumonisin B1 (FB) levels in extruded corn-based products as well as the toxin bioaccessibility upon digestion. Cornmeal contaminated with FB (1.

Condensation Removal Practices and Their Potential for Contributing to Environmental Pathogen Contamination in Food Processing Facilities.

Abstract: Food manufacturers often use squeegees as a tool to remove condensation from overhead surfaces. This practice is done to reduce the likelihood of environmental pathogen contamination by eliminating condensed-water droplets that could fall from overhead surfaces during production. However, this practice may actually spread environmental pathogens across these surfaces, defeating its purpose and further increasing the risk for contamination in the processing area.

Reduction in pathogenic load of wheat by tempering with saline organic acid solutions at different seasonal temperatures.

As a raw agricultural commodity, wheat is exposed to microbial contamination; therefore, enteric pathogens may be among its microbiota creating a food safety risk in milled products. This research evaluates (1) the effectiveness of organic acids dissolved in saline solutions to reduce the counts of pathogenic microorganisms in soft and hard wheat, and also investigates the effect of seasonal temperature on (2) survivability of pathogens in wheat kernels and on (3) pathogen inactivation during tempering with saline organic acid solutions. Wheat samples were inoculated with cocktails of either 5 serovars of Salmonella enterica, 5 E.

Radio-Frequency Processing for Inactivation of Salmonella enterica and Enterococcus faecium NRRL B-2354 in Black Peppercorn.

Several Salmonella outbreaks linked to black pepper call for effective inactivation processes, because current decontamination methods result in quality deterioration. Radio-frequency (RF) heating provides a rapid heating rate and volumetric heating, resulting in a shorter come-up time. This allows for choosing a high-temperature and short-time combination to achieve the desired inactivation with minimal quality deterioration.

Response Surface Methodology for Salmonella Inactivation during Extrusion Processing of Oat Flour.

An increase in the number of foodborne outbreaks and recalls due to Salmonella in low-moisture foods has resulted in the need for the development and validation of process controls to ensure their microbiological safety. Furthermore, the Food Safety Modernization Act Preventive Controls for Human Food final rule requires food processors to validate their process controls to ensure food safety. The objective of this study was to develop a response surface model to predict Salmonella inactivation in oat flour, as affected by moisture, fat content, screw speed, and temperature.

Safety and Quality Assessment of Smallholder Farmers' Maize in the Western Highlands of Guatemala.

Maize ( Zea mays) is a staple in many developing countries but is known to be prone to pest (insects, birds, and rodents) and fungal infestation. In Guatemala, mycotoxin contamination of cultivated products may occur owing to such factors as environmental conditions and the use of traditional agriculture operations. To assess the current maize conditions in Guatemala, a small-scale study was performed.

Evaluation of Enterococcus faecium NRRL B-2354 as a Surrogate for Salmonella During Extrusion of Low-Moisture Food.

Unlabelled: Salmonella in low-moisture foods is an emerging challenge due to numerous food product recalls and foodborne illness outbreaks. Identification of suitable surrogate is critical for process validation at industry level due to implementation of new Food Safety Modernization Act of 2011. The objective of this study was to evaluate Enterococcus faecium NRRL B-2354 as a surrogate for Salmonella during the extrusion of low-moisture food.

A risk assessment of dietary Ochratoxin a in the United States.

Ochratoxin A (OTA) is a mycotoxin (fungal toxin) found in multiple foodstuffs. Because OTA has been shown to cause kidney disease in multiple animal models, several governmental bodies around the world have set maximum allowable levels of OTA in different foods and beverages. In this study, we conducted the first exposure and risk assessment study of OTA for the United States' population.

Isolation and genetic identification of spore-forming bacteria associated with concentrated-milk processing in Nebraska.

Spore-forming bacteria are heat-resistant microorganisms capable of surviving and germinating in milk after pasteurization. They have been reported to affect the quality of dairy products by the production of enzymes (lipolytic and proteolytic) under low-temperature conditions in fluid milk, and have become a limiting factor for milk powder in reaching some selective markets. The objective of this research was to isolate and identify the population of spore-forming bacteria (psychrotrophic and thermophilic strains) associated with concentrated milk processing in Nebraska.

Microbial Load of Hard Red Winter Wheat Produced at Three Growing Environments across Nebraska, USA.

Post-flowering weather variables in farm fields may influence the microbial loads of wheat grain. In this study, the effects of weather variables following wheat flowering on the microbiological quality of wheat were evaluated over two consecutive growing seasons (2011 to 2012 and 2012 to 2013) in the state of Nebraska, USA. Three hard red winter wheat lines, including two commercial cultivars (Overland and McGill) and one experimental line (NW07505), were planted in three regions with contrasting key weather variables (Southeast, South Central, and Panhandle district) to ensure that developing seeds were exposed to different weather conditions.

Physicochemical, Functional and Antioxidant Properties of Tropical Fruits Co-products.

The aim of this study was to determine the physicochemical, functional and antioxidant properties of mango (MAC), pineapple (PAC) and passion fruit (PFC) co-products in order to evaluate them as ingredients for food application. Proximate composition showed low fat content (0.95-5.

Transmission of Escherichia coli O157:H7 to internal tissues and its survival on flowering heads of wheat.

Escherichia coli O157:H7 is a human pathogen that can cause bloody diarrhea, hemorrhagic colitis, and hemolytic uremic syndrome. E. coli O157:H7 illnesses are mainly associated with undercooked beef; however, in recent years, outbreaks have been linked to fresh produce, such as spinach, lettuce, and sprouts.

Characterisation and potential application of pineapple pomace in an extruded product for fibre enhancement.

This study characterised pineapple pomace (PP) and evaluated its application in extrusion to enhance fibre content of the final product. The pomace had low fat (0.61%) and high dietary fibre (45.

Use of Enterococcus faecium as a surrogate for Salmonella enterica during extrusion of a balanced carbohydrate-protein meal.

Multiple outbreaks of salmonellosis have been associated with the consumption of low-moisture products, including extruded products. Therefore, there is a need for a nonpathogenic, surrogate microorganism that can be used to validate extrusion processes for Salmonella. The objective of this research was to determine if Enterococcus faecium NRRL B-2354 is an adequate surrogate organism for Salmonella during extrusion.

Validation of extrusion as a killing step for Enterococcus faecium in a balanced carbohydrate-protein meal by using a response surface design.

Outbreaks of salmonellosis and recalls of low-moisture foods including extruded products highlight the need for the food and feed industries to validate their extrusion processes to ensure the destruction of pathogenic microorganisms. Response surface methodology was employed to study the effect of moisture and temperature on inactivation by extrusion of Enterococcus faecium NRRL B-2354 in a carbohydrate-protein mix. A balanced carbohydrate-protein mix was formulated to different combinations of moisture contents, ranging from 24.

Reduction of fumonisin B₁ in corn grits by twin-screw extrusion.

Unlabelled: This study was designed to investigate the fate of fumonisins in flaking corn grits during twin-screw extrusion by measuring fumonisin B₁ (FB₁) and its analogs with a mass balance approach. Food grade corn grits and 2 batches of grits contaminated with FB₁ at 10 and 50 μg/g by Fusarium verticillioides M-2552 were processed with or without glucose supplementation (10%, w/w) with a twin-screw extruder. Extrusion reduced FB₁ in contaminated grits by 64% to 72% without glucose and 89% to 94% with added glucose.

Extrusion cooking with glucose supplementation of fumonisin-contaminated corn grits protects against nephrotoxicity and disrupted sphingolipid metabolism in rats.

Scope: Fumonisin B1 (FB1) is a mycotoxin found in maize and maize-based foods. It causes animal diseases and is a suspected risk factor for cancer and birth defects in humans. Extrusion cooking reduces FB1 concentrations in maize however toxicity caused by unknown degradation or FB1-matrix reaction products might persist.

Reduced toxicity of fumonisin B1 in corn grits by single-screw extrusion.

Corn grits spiked with 30 microg/g fumonisin B1 and two batches of grits fermented with Fusarium verticillioides (batch 1 contained 33 microg/g, and batch 2 contained 48 microg/g fumonisin B1), which were extruded by a single-screw extruder with and without glucose (10%, dry weight basis) supplementation were fed to rats. Control groups were fed uncontaminated grits. Extrusion with glucose more effectively reduced fumonisin B1 concentrations of the grits (75 to 85%) than did extrusion alone (10 to 28%).

Reduction of fumonisin B1 in corn grits by single-screw extrusion.

This study was designed to determine the efficacy of extrusion in reducing fumonisin B1 in corn flaking grits in the presence and absence of glucose. In addition, degradation products of fumonisin B1 during extrusion were identified and quantitated with a mass balance approach. Uncontaminated clean corn grits, grits spiked with 30 microg/g fumonisin B1, and grits fermented with Fusarium verticillioides M-2552 (40-50 microg/g fumonisin B1) were extruded in the presence and absence of glucose (10%, w/w) using a single-screw extruder.

Stability of mycotoxins during food processing.

The mycotoxins that commonly occur in cereal grains and other products are not completely destroyed during food processing operations and can contaminate finished processed foods. The mycotoxins most commonly associated with cereal grains are aflatoxins, ochratoxin A, fumonisins, deoxynivalenol and zearalenone. The various food processes that may have effects on mycotoxins include sorting, trimming, cleaning, milling, brewing, cooking, baking, frying, roasting, canning, flaking, alkaline cooking, nixtamalization, and extrusion.